HOME     PROJECTS     STORIES     PHOTO WIZARD     ABOUT     WEBSITE

Sunday, September 20, 2009

Fabric Frame Instructions and GIVEAWAY!

You have patiently waited... it's time to roll up your sleeves and create your very own fabric frame.

First you'll want to gather:
Unfinished Wood Frame (our rim measures about three inches across)
Fabric (enough to completely cover the frame)
Black Paint (spray paint or brush on)
Decoupage Glue (we recommend Mod Podge - Matte finish)
Wide Foam Brush
Razor
Sandpaper
Sanding Block
Distress Ink
Distress Chalk

Step 1:
Paint all the edges of the frame. We find that spray paint works great, especially when you're painting several frames at the same time. Over-spray typically doesn't affect your final project since you're covering the frame with fabric. Just be careful if you're using a light-colored fabric. Let the paint dry.

Cut your piece of fabric to be slightly larger than the frame.

Step 2:
Use the wide foam brush to apply an even coat of decoupage glue to the front of the frame. Be sure that the coverage is equally applied to all areas of the frame. The trick here is to not use too much glue, though not enough will cause the fabric to lift.

You'll need to work quickly since the glue will start to dry. Once all the glue is applied, pick up the cut piece of fabric and place it over the frame. We typically start in one corner and move in a clockwise position to make sure that fabric properly covers the entire frame. Try not to reposition the fabric more than is necessary. Smooth the fabric into place rubbing out any air bubbles that might appear. Rub your finger along the edges of the frame to ensure proper adherence.

HINT~ Be sure to lay your frame in front of you in its upright hanging position. This will allow you to properly place the fabric.

Step 3:
Let the glue completely dry. Use a razor to cut off the excess fabric around the outer edge of the fabric. It will cut easily if you hold the excess fabric taut while running the razor blade against the wood frame. Cut out the center in a similar fashion. Start in one corner by feeling the edge of the frame with your finger and creating a small incision with the blade. Once the hole is large enough, you'll be able to hold the fabric tight while continuing to cut away the excess fabric.

Step 4:
Sand all the edges of the frame. We like to use a sanding block (it saves the hands). Just wrap a piece of sand paper around the block and your sanding block will last longer. It is helpful to place the frame over a sink or between two tables especially when sanding the center of the frame. Always sand away from the fabric. If you're sanding the outer edge, start with your sanding block on the edge of the fabric. Slide it towards the back of the frame. Don't sand side to side. You'll notice little stray fibers sticking out; keep sanding! The inner corners can be a bit tricky. You might want to use just the sanding block (without any paper) to clean up the inside corners.

Step 5:
Distress the edges. We like to apply a vintage look to everything we make. Our favorite distress ink color for this project is Vintage Photo. You might want to experiment with different colors based on your personal preference and fabric choices. This pad wont fit into the inside corners of the frame. Use a cat-eye (like our favorite Chestnut Roan fluid chalk by Colorbox) to darken the corners.

Hint ~ A Q-tip works great for getting color into the corners of the frame. Rub a little ink color or paint on to the Q-tip and dab on the frame.

Step 6:
All that's left is to apply a a couple coats of decoupage glue and you're ready to enjoy your efforts. Make sure that you let the ink dry before adding glue to the top of the project. If ink streaks into the middle of the frame you can typically pull the brush back to the edge and remove it. As you apply the glue, the distress ink will darken the fabric; this gives instant age to your project and makes the frame look like it's been around for years!

I think I mentioned that I already found a perfect spot for my new frame. Of course, now I want to paint my walls a new shade of teal. Considering that I never finished the paint job that I started two years ago (maybe it was three) I doubt I'll attempt this room!

Now for the important stuff...
Who wants to win one of these beautiful frames? I bought enough fabric to make the winner their own frame. They can pick either size (we offer sizes with a 12x12 and 8x8 opening). Just add a comment (including the size of the frame that you want) to this post and we'll pick a winner late Wednesday night and post the winner's name on Thursday.

Best of luck to you!

8 comments:

Nancy said...

What a darling frame and great tutorial! Thanks for sharing. If I were to win I would choose the 8x8 opening.
spackattak7 at hotmail dot com

Lori said...

I love these!! I thought they were so beautiful at the Time Out in Logan. Thank you for sharing your wonderful talent. I would chose an 8X8 opening. My email is floppyeared1@msn.com

Louisa said...

I also loved your display at the Time out for Women in Logan. They are beautiful. I would love an 8x8 opening. My email is louisachild@yahoo.com

lovejoy said...

Everything you come up with is absolutely darling, including this frame! I love the idea! I'd love the 8X8.
joyouspring@gmail.com

Kelly said...

Super cute! I would like a 12x12 frame. kelly.vincent@gmail.com

Curley Family said...

I LOVE this! My sister-in-law told me about you and I am hooked! I would LOVE a 12x12!
rnscurley@yahoo.com

Maegan said...

Such a cute idea! I love it. I would choose to have an 8x8. I'll keep my fingers crossed. My email is dwcorry@hotmail.com

Shawn said...

This is so darling!! I would choose 12x12. Thanks for the chance! My email is staceyj@comcast.net